[1]李太民,王业宇,吉庆伟,等.大型立式轴流泵变频反向发电压力脉动特性分析[J].江苏水利,2019,(07):69-72.
　LI Taimin,WANG Yeyu,JI Qingwei,et al.Analysis on the pressure pulsation characteristics of large-scale vertical axial flow pump with rotation frequency inverted power generation[J].JIANGSU WATER RESOURCES,2019,(07):69-72.
点击复制

大型立式轴流泵变频反向发电压力脉动特性分析()
分享到：

《江苏水利》[ISSN:1006-6977/CN:61-1281/TN]

卷:
期数:
2019年07期
页码:
69-72
栏目:
水利工程管理
出版日期:
2019-07-19

文章信息/Info

Title:
Analysis on the pressure pulsation characteristics of large-scale vertical axial flow pump with rotation frequency inverted power generation
文章编号:
1007-7839(2019)07-0069-04
作者:
李太民;  王业宇;  吉庆伟;  韩 宁;  祁德丽
江苏省骆运水利工程管理处, 江苏 宿迁 223800
Author(s):
LI Taimin;  WANG Yeyu;  JI Qingwei;  HAN Ning;  QI Deli
Luoyun Hydraulic Project Management Division of Jiangsu Province, Suqian 223800, Jiangsu
关键词:
轴流泵;  反向发电;  压力脉动;  转频
Keywords:
axial flow pumps;  inverted power generation;  pressure pulsation;  rotation frequency
分类号:
TV675
文献标志码:
B
摘要:
为研究水泵在反转发电时,转速对水泵性能的影响,对水泵在变频反向发电工况下进行全流道数值模拟。可知:水泵在进行反向变频发电时,流线较一般水轮机流线图分布差,出转轮部分水流出现絮乱; 压力脉动幅值在出转轮处最大,进转轮处次之,进导叶时最小,最大压力脉动系数为0.56,约为进转轮的20倍。压力脉动幅值沿转轮中心向转轮边缘逐渐增大,边缘处压力脉动系数约为转轮中心处的8倍; 水流受转轮转动影响严重,进出转轮截面水流压力脉动主频为叶频,次频为转频。
Abstract:
In order to study the influence of the rotational speed on the performance of the pump when the pump was in inverted power generation, the full-flow numerical simulation of the pump under the condition of rotation frequency inverted power generation was carried out. It was concluded that the distribution of flow line was worse than that of general turbine when pumps generate electricity by reverse frequency conversion, and the flow of the outlet runner was confused. The pressure pulsation amplitude was the largest at the rotor, the second at the runner, and the smallest when entering the guide vane. The maximum pressure pulsation coefficient was 0.56, which was about 20 times that of the runner. The pressure fluctuation amplitude increased gradually along the center and the edge of the runner, and the pressure fluctuation coefficient at the edge was about 8 times that at the center of the runner. The flow was seriously affected by the rotation of the runner. The main frequency of pressure pulsation in and out of the runner section was blade frequency, and the secondary frequency was rotation frequency.

参考文献/References:

[1] 袁寿其, 薛菲, 袁建平. 离心泵压力脉动对流动噪声影响的试验研究[J]. 排灌机械工程学报, 2009, 27(5):287-290.
[2] 施卫东, 冷洪飞, 张德胜, 等. 轴流泵内部流场压力脉动性能预测与试验[J]. 农业机械学报, 2011, 42(5):44-48.
[3] 郑源, 张飞, 蒋小欣, 等. 贯流泵装置模型试验叶轮出水口压力脉动研究[J]. 流体机械, 2007, 35(1):1-3.
[4] 汤方平, 张丽萍, 付建国, 等. 轴流泵内部压力脉动数值预测及分析[J]. 排灌机械工程学报, 2013, 31(10):835-840.
[5] 李辰光, 王福军, 许建中. 两级双离心泵压力脉动特性[J]. 农业机械学报, 2011, 42(7):41-42.
[6] 董兴华, 郭艳磊, 毕祯, 等. 基于CFX与Workbench耦合的轴流泵的内外特性[J]. 排灌机械工程学报, 2015(6):488-493.
[7] 施卫东, 王国涛, 张德胜, 等. 基于流固耦合的轴流泵叶片应力特性[J]. 排灌机械工程学报, 2013, 31(9):737-740.
[8] 钱忠东, 陆杰, 郭志伟, 等. 水泵水轮机在水轮机工况下压力脉动特性[J]. 排灌机械工程学报, 2016, 34(8):672-678.

相似文献/References:

[1]孙丹丹,高 慧,王 刚,等.立式轴流泵装置进出水流道多方案优选[J].江苏水利,2018,(11):35.
　SUN Dandan,GAO Hui,WANG Gang,et al.Multiple schemes optimization for inlet and outlet flow of vertical axial flow pump device[J].JIANGSU WATER RESOURCES,2018,(07):35.
[2]徐 斌,徐文奕,殷允涛.南水北调刘老涧二站反向发电实践[J].江苏水利,2019,(04):59.
　XU Bin,XU Wenyi,YIN Yuntao.Reverse power generation practice of Liulaojian No.2 Pumping Station in South-to-North Water Diversion Project[J].JIANGSU WATER RESOURCES,2019,(07):59.
[3]朱晓明,张东培,周 斌,等.大型立式轴流泵进水流道两点压差式测流法研究[J].江苏水利,2019,(10):23.
　ZHU Xiaoming,ZHANG Dongpei,ZHOU Bin,et al.Study on the two-point differential pressure type flow measurement method for inlet flow channel of large vertical axial flow pum[J].JIANGSU WATER RESOURCES,2019,(07):23.
[4]张庆宏,施卫东,谢占山,等.不同出水口淹没深度的轴流泵性能及内部湍流特征[J].江苏水利,2021,(09):1.
　ZHANG Qinghong,SHI Weidong,XIE Zhanshan,et al.Performance and internal turbulence characteristics of axial flow pump with different outlet submerged depth[J].JIANGSU WATER RESOURCES,2021,(07):1.
[5]李松柏,孙涛,成立,等.大型立式轴流泵站典型故障调查分析[J].江苏水利,2022,(03):36.
　LI Songbai,SUN Tao,CHENG Li*,et al.Investigation and analysis on typical faults in large vertical axial flow pumping station[J].JIANGSU WATER RESOURCES,2022,(07):36.
[6]王丽,施伟,刘连建,等.导叶角度对轴流泵高效区运行范围的影响[J].江苏水利,2023,(05):17.
　WANG Li,SHI Wei,LIU Lianjian,et al.Influence of the angle of the guide vane on the operating range of the high efficiency zone of the axial flow pump[J].JIANGSU WATER RESOURCES,2023,(07):17.
[7]李蕴升,庄伟栋,汤国庆,等.某大型轴流泵叶片角度测量显示装置技术改造探讨[J].江苏水利,2024,(05):52.
　LI Yunsheng,ZHUANG Weidong,TANG Guoqing,et al.Discussion on technology transformation of blade angle measurement display device for a large axial flow pump[J].JIANGSU WATER RESOURCES,2024,(07):52.
[8]范云逸,周鹏,陈岗,等.基于能量损失模型的轴流泵空化特性研究[J].江苏水利,2024,(08):26.
　FAN Yunyi,ZHOU Peng,CHEN Gang,et al.Study on cavitation characteristics of axial flow pump based on energy loss model[J].JIANGSU WATER RESOURCES,2024,(07):26.

备注/Memo

备注/Memo:
收稿日期:2018-11-19
作者简介:李太民(1963—),男,本科,高级工程师,主要从事大型水利工程管理工作。
更新日期/Last Update: 2019-07-15